Gasboy CFN Series Site Controller III Bedienungsanleitung PDF herunterladen (Seite 81)

MDE-4298D CFN Series Site Controller III Installation Manual · September 2009 Page 77

Installation Completion Checklist Testing

6 – Testing

Installation Completion Checklist

The information below should be reviewed to help verify proper installation of the CFN

system prior to testing pumps and/or remote dispensers in the manual override position.

• Are the CFN system components located in the proper environment as described in

“Purpose” on page 9?

• Is there adequate clearance around the ICRs (refer to “Purpose” on page 9, “ICR” on

page 14, and “ICR2 (PA0398X0XXX0)” on page 18)?

• Is all the wiring inside the metal conduit, except as noted in “Short Haul Modem (SHM)

RS-422” on page 39?

• Is the AC and DC wiring in separate conduits, troughs, and so on? If they are not, and if

the AC and DC wires share the conduit, a shielded cable must be used as specified in

“Communication Requirements” on page 33, “RS-485” on page 33, “Short Haul Modem

(SHM) RS-422” on page 39, or “Pulser Wiring and Configuration” on page 53.

• Are the CFN system components on a separate dedicated breaker (refer to “System

Components Wiring” on page 31)

• Are pumps over 3/4 HP at 120/240 VAC or 1-1/2 HP at 240 VAC equipped with a starter

relay (refer to “Pump/Remote Dispenser Wiring” on page 43)?

• Is the correct gauge wire installed for the following:

- System (refer to “System Components Wiring” on page 31)?

- Pumps (refer to “Pump/Remote Dispenser Wiring” on page 43)?

- Remote dispensers (refer to “Pump/Remote Dispenser Wiring” on page 43)?

- Pulsers (refer to “Pump/Remote Dispenser Wiring” on page 43)?

- SHMs (refer to “System Components Wiring” on page 31)?

• Are the communication lines under the maximum allowable distance for the following:

- RS-232 - 100 feet (refer to “System Components Wiring” on page 31)?

- RS-485 - 1000/1500 feet (refer to “System Components Wiring” on page 31)?

- RS-422 (SHMs) - 1500 feet (refer to “System Components Wiring”

on page 31)?

• If the system has an external modem, is the phone line installed (refer to “System

Components Wiring” on page 31)?

• Is there fuel in the tanks?

1 2 ... 76 77 78 79 80 81 82 83 84 85 86

Keine Kommentare

Gasboy CFN Series Site Controller III Bedienungsanleitung Seite 81